zukgod1
01-12-2009, 08:55 AM
SOLD!!
1990 Jetta GL Turbo Diesel
Engine;
New 1.6 Turbo Diesel
Bored to 1mm over for new German pistons.
Total Seal rings
ARP head studs
Valve job, seals. New precups installed
MLS head gasket (1 notch)
New German bearings, crank and rods
IM shaft bearings replaced as well.
36mm oil pump.
Saab thermo oil cooler, cor mounted in front of rad.
Hybrid turbo, k24 hot side with k26 cold side and all new bearings and
seals.
Full 3" turbo back exhaust exiting through an Magnaflow muffler and a 4" SS turndown tip.
New 10mm Injection pump with 1.9aaz cam disk (stock was 8mm)
New Injectors with GTD tips
Rubber pan gasket with windage tray.
G60 valve cover powder coated BLK (if it ever comes back from the powder
coater that is) rubber gasket thre as well.
Boost, EGT and oil pressure mounted in dash. Autometer Ultra lite II's.
New radiator with mk3 duel fans.
Has a Front mount intercooler as well.
Pusher fuel pump mounted back by tank.
Fuel filter housing off a 01 Dodge Cummins, filters are available every where.
New 22mm master cyl, Audi G60 duel piston calipers on corrado 11" rotors, SS
lines f/r. Mk3 knuckles w/ new bearings. Passat rear disks.
Replaced the AWY trans with an ACN .75 for the 5th gear.
SACHS Super Clutch pressure plate with a lightened flywheel and a Clutchnet.net 8 puck disc.
Shift linkage completely replaced.
Mk5 leather shift know and steering wheel.
Tilt column.
Recaro GLI seats front and rear, kept the OE door cards and added ACTIV speaker pockets.
Replaced the Blue carpet with black. Laid the Back over the top of the Blue for extra insulation and sound damaging.
Tinted windows, 5% rear 50% fronts windshield also. Can remove windshield tint for buyer if requested.
No stereo, gauges installed in Dash.
Replaced dash with a pristine one from a salvage yard, no cracks.
Diesel cluster with Tach that works.
Swapped out door sealt belts for reg B Piller mounted ones.
KYB GR2 struts and Neuspeed springs (about 1.5")
New strut bearings as well.
Air conditioning is complete and works great as well.
Keskins KTN5's 16x7.5 front 16x9 rear with 204/40-215/40 Zeiks and about 80% tread.
Air conditioning is complete and works great as well.
Body is in good condition for a 1990 car. The only rust on it is under the windshield and it's not terminal but it need to be noted.
I removed the small bumpers from this car and added bigs, I also added the flares and skirts. I still have the smalls if the buyer wants them as well as the original interior that is in good condition as well.
Head lights are Smokes Euro E Codes
Has mk3 Chinese door handles which I dont care for, I also have the original door handles that go with the car as well.
There is also an alarm already installed with built in pager.
I will up date this as I remember more, feel free to ask questions.
Price is $5500.00. If you want it shipped you will pay for that of course and if you decide to pay through Paypal a 4% PITA fee will need to be added and funds will have to clear before car is handed over. I need something larger and with a automatic transmission so I'm giving up my 40+ MPG in search of a B5 1.8t
http://i176.photobucket.com/albums/w168/zukgod1/Stance.jpg
1990 Jetta GL Turbo Diesel
Engine;
New 1.6 Turbo Diesel
Bored to 1mm over for new German pistons.
Total Seal rings
ARP head studs
Valve job, seals. New precups installed
MLS head gasket (1 notch)
New German bearings, crank and rods
IM shaft bearings replaced as well.
36mm oil pump.
Saab thermo oil cooler, cor mounted in front of rad.
Hybrid turbo, k24 hot side with k26 cold side and all new bearings and
seals.
Full 3" turbo back exhaust exiting through an Magnaflow muffler and a 4" SS turndown tip.
New 10mm Injection pump with 1.9aaz cam disk (stock was 8mm)
New Injectors with GTD tips
Rubber pan gasket with windage tray.
G60 valve cover powder coated BLK (if it ever comes back from the powder
coater that is) rubber gasket thre as well.
Boost, EGT and oil pressure mounted in dash. Autometer Ultra lite II's.
New radiator with mk3 duel fans.
Has a Front mount intercooler as well.
Pusher fuel pump mounted back by tank.
Fuel filter housing off a 01 Dodge Cummins, filters are available every where.
New 22mm master cyl, Audi G60 duel piston calipers on corrado 11" rotors, SS
lines f/r. Mk3 knuckles w/ new bearings. Passat rear disks.
Replaced the AWY trans with an ACN .75 for the 5th gear.
SACHS Super Clutch pressure plate with a lightened flywheel and a Clutchnet.net 8 puck disc.
Shift linkage completely replaced.
Mk5 leather shift know and steering wheel.
Tilt column.
Recaro GLI seats front and rear, kept the OE door cards and added ACTIV speaker pockets.
Replaced the Blue carpet with black. Laid the Back over the top of the Blue for extra insulation and sound damaging.
Tinted windows, 5% rear 50% fronts windshield also. Can remove windshield tint for buyer if requested.
No stereo, gauges installed in Dash.
Replaced dash with a pristine one from a salvage yard, no cracks.
Diesel cluster with Tach that works.
Swapped out door sealt belts for reg B Piller mounted ones.
KYB GR2 struts and Neuspeed springs (about 1.5")
New strut bearings as well.
Air conditioning is complete and works great as well.
Keskins KTN5's 16x7.5 front 16x9 rear with 204/40-215/40 Zeiks and about 80% tread.
Air conditioning is complete and works great as well.
Body is in good condition for a 1990 car. The only rust on it is under the windshield and it's not terminal but it need to be noted.
I removed the small bumpers from this car and added bigs, I also added the flares and skirts. I still have the smalls if the buyer wants them as well as the original interior that is in good condition as well.
Head lights are Smokes Euro E Codes
Has mk3 Chinese door handles which I dont care for, I also have the original door handles that go with the car as well.
There is also an alarm already installed with built in pager.
I will up date this as I remember more, feel free to ask questions.
Price is $5500.00. If you want it shipped you will pay for that of course and if you decide to pay through Paypal a 4% PITA fee will need to be added and funds will have to clear before car is handed over. I need something larger and with a automatic transmission so I'm giving up my 40+ MPG in search of a B5 1.8t
http://i176.photobucket.com/albums/w168/zukgod1/Stance.jpg